热缩电缆中间接头制作安装.docx

《热缩电缆中间接头制作安装.docx》由会员上传分享，免费在线阅读，更多相关内容在应用文档-天天文库。

1、热缩电缆中间接头制作安装作业指导书目次1适用范围······················································································································································1232编写依据···················································································································

2、···································1233作业流程图··················································································································································1234安全风险辨析与预控······························································································

3、····································1235作业内容······················································································································································124DLFJAZ-04热缩电缆中间接头制作安装作业指导书1适用范围1.1电压等级35kV及以下配网工程。1.2电气类别热缩电缆接头安装。2编写依据表2-1编写依据序号引用资料名称相关章节条款1GB501

4、68—2006《电气装置安装工程电缆线路施工及验收规范》第六章2DL/T5161.5—2002《电气装置安装工程质量检验及评定规程第5部分：电缆线路施工质量检验》3GB50217—2007《电力工程电缆设计规范》4Q/CSG11105—2008《南方电网工程施工工艺控制规范》第二篇第九章第二节5GB50303—2002《建筑电气工程施工质量验收规范》6《中国南方电网有限责任公司基建工程质量控制作业标准（WHS）》3作业流程图4安全风险辨析与预控图3-1作业流程图序号1安全风险机械伤害表4-1工作前安全风险辨析及预控措施表预控措施电缆压接前，应确认液压钳的钳体、液压管及连接口等部位

5、完好无损后才使用，以免设备爆裂伤人压接电缆时，严禁将手指伸入压模内用刀或其他工具时，刃口不准对着人体检查结果123表4-1（续）序号安全风险预控措施检查结果邻近运行中设备或在运行中电缆坑道内作业必须按规定办理工作票对作业坑道内和邻近的运行中设备采取有效的保护措施加强使用前及使用过程中的检查，保护零线与工作零线不得混接，开关箱漏电保护器灵敏可靠，漏电保护装置参数应匹配，严格执行“一机、一闸、一漏、一箱”的要求用电管理和检修维护必须规范，并由专业电工进行，配电箱必须上锁，并采取防雨措施电动工具，在使用前应检查外壳接地线是否良好，引出线有无损坏安全带应系在牢固的构件上，高处作业转位时，不得

6、失去安全带保护路边制作电缆接头，施工现场必须做好安全围蔽及警示标志措施，防止外人进入工作区域，防止行人进入施工范围；施工人员必须穿工作服，正确佩戴安全帽电缆坑盖打开后设置围栏，晚上设置夜间警示灯，防止人员跌落电缆坑避开中午炎热时间段户外作业配置太阳伞，室内配置排风扇，人员轮流休息供应清凉含盐饮料5车辆伤害在道路旁边进行导、地线连接时，施工人员要穿戴反光标志的工作服，要按规定提前设置警示标志，要派专人看守监护或协助疏导交通6淹溺在跨越江河水面施工作业时，工作人员应会游泳并正确穿戴救生衣7火灾动火作业必须按规定办理动火工作票焊锡施工时，要防止焊嘴烫伤人体烧焊作业时要戴防护眼镜、脚罩、手套严格

7、执行持证上岗制度，焊工必须持证上岗9中毒窒息电缆隧道、电缆坑道内作业前做好毒气检测工作，进入坑道前先进行通风并有良好的通风措施请您认真检查并签名确认，您的签名意味着将承担相应的安全质量责任。施工单位检查人：日期：监理单位检查人：日期：注：对存在风险且控制措施完善填写“√”，存在风险而控制措施未完善填写“×”，不存在风险则填写“―”，未检查项空白。5作业内容5.1作业前施工条件表5-1作业前施工条件124序号1项目任务单内