常减压装置拆除施工方案

《常减压装置拆除施工方案》由会员上传分享，免费在线阅读，更多相关内容在行业资料-天天文库。

1、中海石油东营石化有限公司7万吨/年常减压装置拆除施工方案工程名称：7万吨/年常减压装置拆除工程工程地点：中海石油东营石化厂区编制单位：生产技术部编制：编制日期：年月日审核：审核日期：年月日批准：批准日期：年月日第10页共10页目录一、工程概况······························································3二、主要施工内容·························································3三、编制依据···········

2、···················································3四、人员组织······························································3五、施工要求·····························································4六、施工进度表··························································5七、拆除施工方式····

3、······················第10页共10页·······························67.1、施工方法····························································67.1.1、设备、储罐及管道置换及清理·····································67.1.2、管道拆除··························································67.1.3、燃料油罐

4、拆除·····················································67.1.4、外保温的拆除·····················································67.1.5、吊卸·······························································67.1.6、现场清理··························································7第10页

5、共10页八、现场施工安全及防护措施·············································7一、工程概况根据中海石油炼化有限责任公司【海油炼化财[2013]268号】文件要求，中海石油东营石化有限公司决定于2014年3月对7万吨/年常减压装置进行拆除工作。二、主要施工内容：1、7万吨/年常减压装置管廊上部约930米工艺管道，一个燃料油罐；2、装置区管廊支架；3、两台真空泵、两个水冷槽、常炉龙门架及空冷平台；4、工艺平台及两塔附属管线。三、编制依据1、《石油化工剧毒、可燃介质管道工程施工及验收规范

6、》SH3501-20022、《现场设备、工艺管道焊接工程施工及验收规范》GB50236－983、《工业金属管道工程施工及验收规范》GB50235－974、《石油化工施工安全技术规定》SH3505－20045、《石油化工静电接地设计规范》SH3097－20006、《中海石油东营石化有限公司QHSE管理制度》四、人员组织为确保7万吨/年常减压装置安全拆除，达到“有组织、有计划，有方案”施工，成立中海石油东营石化有限公司7万吨/年常减压装置拆除领导小组。组长：韩祚平第10页共10页副组长：李德录小组成员：赵树梁、张文光、荣爱民、禹建福

7、领导小组下设3个专业组：（1）工艺排查组：组长：荣爱民组员：季善义、吴爱峰工艺排查组职责：负责对7万吨/年常减压装置危险源摸底排查，现场确认每天达到施工条件的工作量。（2）安全监管组:组长：赵树梁组员：张红兵、武玉强、刘相伟安全监管组职责：负责现场各项安全监管及应急事故处理。（3）现场施工组：组长：张文光组员:禹建福、刘宇、蔺志伟现场管理组职责：负责施工方案确定与现场施工安全及进度管理，保证拆除工作有序开展。五、施工要求1、本工程的施工区域位于油品罐区东侧，维修中心焊工班南侧，且周边有各种施工剩余材料，现场条件相对复杂，在施工过

8、程中要严格按照拆除方案进行施工。2、施工期间严格按照“以人为本，安全第一”理念，从外围慢慢向内部渗透，按照计划进行拆除。3、在拆除过程中由于施工场地面积较小应随拆随清，防止废料堆积影响施工进度。4、根据施工组织人员分配，在施工过程中需遵循以下几点要求：（1）施工