欢迎来到天天文库
浏览记录
ID:32355147
大小:2.80 MB
页数:62页
时间:2019-02-03
《led模组的玻璃散热结构与其优化》由会员上传分享,免费在线阅读,更多相关内容在学术论文-天天文库。
1、华中科技大学硕士学位论文摘要近些年来,由于LED具有响应时间快、发光效率高、使用寿命长等特点,其被广泛应用于照明领域、医疗等领域。可以预见,LED将会取代传统的白炽灯、节能灯,成为照明领域的主流。传统的散热材料各有优缺点。本文提出了使用普通玻璃作为散热器的想法,并提出了两种利用玻璃作为散热器的基本模型,即平板玻璃和玻璃管结构。对于平板玻璃LED光源模组,长度对结温的影响较小;平板玻璃LED模组的稳态最高温度随着平板玻璃宽度的增加而下降,而且在平板玻璃宽度超过12mm时下降趋势减缓;平板玻璃LED模组的稳态最高温度随着平板玻璃厚度的增
2、加而下降,在平板玻璃厚度大于4mm时,这种下降趋势减缓。并设计了一款平板玻璃LED灯具,其最高热功率为1.26W,并且发现灯具的结温与放置方向的关系并不大,并制作了样品,测试了结温。对于玻璃管LED光源模组,对于一定直径的不封口的玻璃管散热器来说,会有一个最佳壁厚,这个壁厚随着直径的增加而增大;随着玻璃管直径的增加,玻璃管LED光源模组的最高结温整体呈下降趋势,下降趋势不断减缓;同样条件下,玻璃管不封口的模组的结温要比封口的结温要低;对于不封口的玻璃管光源模组,会存在一个结温最低的放置角度。设计了玻璃管散热的T6和T8LED日光灯的
3、模型,并证明这种日光灯结构是可行的。设计了3管和7管玻璃LED模组和灯具的结构,并制作样品、测试了结温。提出了使用大面积的导热能力强的材料作为导热材料,玻璃作为散热结构来解决高热流密度的情况。通过在平板玻璃LED光源模组中的光源下方增加一层0.3mm厚的铝合金板,至少可以使单位长度上最高热功率提高23%;将七玻璃管LED灯中间的一根玻璃管换成铝管,至少可以使最高热功率提高25%,将铝管换成与线型LED光源接触良好的铝芯时,最高热功率会更高。关键词:LED光源模组;玻璃散热器;热模拟;LED结温;热流密度I华中科技大学硕士学位论文AB
4、STRACTInrecentyears,forafastresponsetime,highluminousefficiency,longlifeandothercharacteristics,LEDsarewidelyusedinlighting,medicalandotherfields.ItcanbepredictedthatLEDswillreplacetraditionalincandescent,fluorescentlampsandbecomethemainstreamofthelightingfield.Thetrad
5、itionalmaterialsofheatsinkshavetheiradvantagesanddisadvantages.Thispaperproposestheideaoftheuseofglassasaradiatorandtwobasicmodelsofradiatorsusingofglass,namelyflatglassandglasstubestructure.ForflatglassLEDlightsourcemodule,theaffectionofthelengthissmallerthanthewidtha
6、ndthethicknesstothejunctiontemperature.ThemaximumtemperatureoftheflatglassLEDmoduledecreaseswiththeincreasingofthewidth,andthedownwardtrendslowswhentheflatglassiswiderthan12mm.ThemaximumtemperatureoftheflatglassLEDmoduledecreaseswiththeincreasingofthethickness,andthedo
7、wnwardtrendslowswhentheflatglassisthickerthan4mm.AflatglassLEDlampisdesigned,andthemaximumthermalpowerof1.26W.Itisfoundthattherelationshipbetweenthejunctiontemperatureofthelampandorientationsisweak.Asampleisproduced,anditsjunctiontemperatureistested.FortheglasstubeLEDl
8、ightsourcemodulewithanunsealedglasstuberadiatorofacertaindiameter,thereisapreferredthicknesswhichincreaseswithincreas
此文档下载收益归作者所有